Wyoming Refining Co. Clean Air Act Settlement

(Washington, D.C. - Feb. 10, 2009) Two petroleum refiners have agreed in separate settlements to spend a total of more than $141 million in new air pollution controls at three refineries in Kansas and Wyoming the U.S. Environmental Protection Agency and the Justice Department announced today. The settlements are expected to reduce harmful emissions by 7,000 tons per year.

On this page:

Geography
Refining Capacity
Emissions reductions
Injunctive Relief
Environmental Benefits
Penalty
State Partner
Comment Period

Geography:

One refinery in Newcastle, Wyoming

Refining Capacity:

Approximately 12,500 bbl/day
Less than 0.1% percent of U.S. domestic refining capacity

Emissions reductions:

Nitrogen oxide (NO_x) reduced by more than 20 tons per year
Sulfur dioxide (SO₂) reduced by more than 788 tons per year
Additional reductions of volatile organic compounds (VOCs), particulate matter (PM) and other pollutants

Injunctive Relief:

$14 million will be spent in injunctive relief through 2012.

New Source Review/Prevention of Significant Deterioration (NSR/PSD) -- Fluidized catalytic cracking units (FCCUs) and Heaters and Boilers:

FCCU NO_x limits of not more than 50 ppm (365-day) and 100 ppm (7-day)
- If refinery converts FCCU to a "partial burn" operation, NO_x limits are not more than 20 ppm (365-day) and 40 ppm (7-day).
FCCU SO₂ limits of 25 ppm (365-day) and 50 ppm (7-day).
- Installation of a wet gas scrubber.
Installation of NO_x and SO₂ continuous emission monitors.
Installation of Ultra Low NO_x Burners (or equivalent technology) that are designed to achieve an emission rate of 0.030 lb NO_x/mmBTU for heaters and boilers greater than 40 MMBtu/hr.
Particulate emissions limits of 0.5 pound per 1,000 pounds coke burned at the FCCU.
Carbon monoxide emission limit of 500 ppm on a 1-hour average basis at the FCCU.

New Source Performance Standards (NSPS) and Flaring:

Flare, heaters and boilers subject to NSPS Subpart J.
No fuel oil burning except in limited circumstances.
A "root cause" analysis for all future flaring events.

Benzene Waste Operations National Emissions Standards for Hazardous Air Pollutants (NESHAP):

Total annual benzene (TAB) of less than 10 Mg/yr.
Modified management of change procedures to ensure that new benzene streams are included in the TAB calculation.
Conduct laboratory audits.
Quarterly sampling and TAB calculation.
Training for those who sample benzene.

Leak Detection and Repair Program:

Refinery-wide compliance with LDAR requirements.
Training, including refresher courses, for refinery personnel with LDAR responsibility.
Required LDAR compliance audits.
Strict internal leak definitions (500 ppm for valves and 2000 ppm for pumps).
Internal first attempt at repair at 200 ppm for valves.
More frequent monitoring than required by regulation.

Environmental Benefits:

When all controls are installed, the settlement will result in substantial reductions of the following pollutants:

Nitrogen oxide (NO_x) , which can cause or contribute to a variety of health problems and adverse environmental impacts, such as ground-level ozone, acid rain, global warming, water quality deterioration, and visual impairment. Affected populations include children, people with lung diseases such as asthma, and exposure to these conditions can cause damage to lung tissue for people who work or exercise outside.

Sulfur dioxide (SO₂₎ , which in high concentrations can affect breathing and may aggravate existing respiratory and cardiovascular disease. Sensitive populations include asthmatics, individuals with bronchitis or emphysema, children, and the elderly. SO₂ is also a primary contributor to acid deposition, or acid rain.

Volatile Organic Compounds (VOCs), which -- along with NO_x -- plays a major role in the atmospheric reactions that produce ozone, which is the primary constituent of smog. People with lung disease, children, older adults, and people who are active can be affected when ozone levels are unhealthy. Ground-level ozone exposure is linked to a variety of short-term health problems, including lung irritation and difficulty breathing, as well as long-term problems, such as permanent lung damage from repeated exposure, aggravated asthma, reduced lung capacity, and increased susceptibility to respiratory illnesses such as pneumonia and bronchitis.

Particulate Matter (PM), especially fine particles, contain microscopic solids or liquid droplets that are so small that they can get deep into the lungs and cause serious health problems. PM is linked to a variety of problems, including increased respiratory symptoms such as irritation of the airways, coughing, or difficulty breathing, decreased lung function, aggravated asthma, and premature death in people with heart or lung disease.

For more information on NO_x, SO₂, PM and VOCs, please visit EPA's Air Pollutants Web Site.

Penalty:

$150,000 (split equally with the State of Wyoming)

State Partner:

Wyoming

Comment Period:

The proposed settlement, lodged in the U.S. District Court for the District of Wyoming, is subject to a 30-day public comment period and final court approval. Information on submitting comment is available at the Department of Justice website.

For more information, contact:

Patrick W. Foley
Senior Environmental Engineer
U.S. Environmental Protection Agency (2242A)
1200 Pennsylvania Ave., N.W.
Washington, DC 20460-0001
(202) 564-7978
foley.patrick@epa.gov